压电阻抗技术监测固体推进剂老化研究

doi:10.13675/j.cnki. tjjs. 180521

推进技术 ›› 2019, Vol. 40 ›› Issue (8): 1912-1920.DOI: 10.13675/j.cnki. tjjs. 180521

• 材料推进剂燃料 • 上一篇

压电阻抗技术监测固体推进剂老化研究

1.火箭军工程大学导弹工程学院;2.武汉大学土木建筑工程学院，湖北武汉;430072

发布日期:2021-08-15

Impedance Characterization and Validation of Solid Propellant Based on Electro-Mechanical Impedance Method

1.College of Missile Engineering,Rocket Force University of Engineering,Xi’an 710025,China;2.School of Civil Engineering,Wuhan University,Wuhan 430072,China

Published:2021-08-15

摘要/Abstract

摘要： 为了进一步研究表面粘贴式的主动传感技术——压电阻抗技术（EMI， Electro-Mechanical Impedance）监测固体推进剂的老化，构建了基于线粘弹杆结构的一维机电耦合模型，根据粘弹性波的理论与边界条件进行分析，建立一种线粘弹结构动态模量与其机械阻抗的表征关系，并对构建的机电耦合阻抗模型进行了数值计算及试验验证。针对HTPB固体推进剂开展高温热加速老化试验及压电主动激励试验，根据监测所得导纳频谱并通过提取结构机械阻抗进行分析，结果表明：压电陶瓷片与推进剂结构在高频机电耦合运动时（300kHz，280kHz）有明显的共振现象，结构固有频率高于机电耦合共振频率，并且在200kHz~400kHz频段与700kHz~900kHz频段内，结构机械阻抗频谱峰值会因固体推进剂的热老化时间增长而降低，且与热老化时间之间满足线性关系。由此可见，压电阻抗法能够与固体推进剂在力学性能上建立表征关系，通过得到固体推进剂结构机械阻抗能够监测其老化损伤。

关键词: 固体推进剂;压电阻抗法;机械阻抗;动态模量;老化

Abstract: In order to further study the aging of solid propellants by the Electro-mechanical impedance (EMI) method of surface paste, a one-dimensional electromechanical coupling model based on linear viscoelastic rod structure was constructed. Based on the theory of viscoelastic waves and boundary conditions, a relationship between the complex modulus of solid propellant and its mechanical impedance was established. Numerical calculation and experimental verification of the electromechanical impedance model were carried out. High-temperature thermal accelerated aging experiments and piezoelectric active excitation experiments for HTPB solid propellants were carried out, and according to the admittance spectrum obtained from monitoring, the structural mechanical impedance is extracted and analyzed. The results show that when the piezoelectric ceramic plate is coupled with the propellant structure, it has obvious resonance phenomenon when it moves at high frequency（300kHz，280kHz）. The natural frequency of the structure is higher than the electromechanical coupling resonance frequency. Moreover, The peak value of mechanical impedance spectrum in 200kHz ~ 400kHz and 700kHz ~ 900kHz will decrease with the increase of thermal aging time of solid propellant, and there is a linear relationship between the peak value and thermal aging time.It can be seen that the mechanical properties of the solid propellant can be characterized by the EMI method, by obtaining the mechanical impedance of the solid propellant structure, the aging damage can be monitored.

Key words: Solid propellant;Electro-mechanical impedance method;Mechanical impedance;Dynamic modulus;Aging

. 压电阻抗技术监测固体推进剂老化研究[J]. 推进技术, 2019, 40(8): 1912-1920.

参考文献

[1] 秦浩, 杜仕国，闫军，等. 固体推进剂老化性能研究进展[J]. 化工进展， 2013， 32(8): 1862-1865.
[2] Layton L H. Chemical Structural Aging Effects[R]. AD-002836， 1974.
[3] Cunliffe A V， Qineti Q D A， Evenoaks G B. Sol Fraction Measurements a Tool to Study Cross-Linking and Ageing in Composite Propellants and PBXs[C]. Karlsruhe: 37th International Annual Conference of ICT， 2006.
[4] Kadiresh P N， Ridhar B T N. Experimental Evaluationand Simulation on Aging Characteristics of Aluminised AP-HTPB Composite Solid Propellant[J]. Materials Science and Technology， 2008 ， 4(4): 406-412.
[5] 张昊，彭松，庞爱民，等. NEPE推进剂力学性能与化学安定性关联老化行为及机理[J]. 推进技术， 2007， 28(3)， 327-330.
[6] Cerri S， Bohn M A， Menke K， et al. Aging Behaviour of HTPB Based Rocket Propellant Formulations[J]. Central European Journal of Energetic Materials， 2009， 6 (2): 149-165.
[7] 张兴高，张炜，芦伟，等. 定应变贮存条件下HTPB推进剂填料/黏合剂界面性能[J]. 推进技术， 2009， 30(4): 484-489.
[8] 阳建红，俞茂宏，侯根良，等. HTPB 复合固体推进剂含损伤和老化本构研究[J]. 推进技术， 2002， 23(6):509-512.
[9] 任宁莉，赵新强，邓凯，等. HTPB固体推进剂老化性能检测新方法[J]. 推进技术， 2011， 32(5): 728-731.
[10] Brouwer G R， Weterings F P， Keizers H. Evaluation of Ageing in Composite Propellant Grains Part 2[C]. California: 41st AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit， 2005.
[11] 高鸣，任海峰. 固体仪器发动机健康监测技术评述与研究[J]. 固体火箭技术， 2013， 36(2): 278- 284.
[12] Ruderman G A. Health Management Issues and Strategy for Air Force Missiles[C]. Huntsville: 1st International Forum on Integrated System Health Engineering and Management in Aerospace， 2005.
[13] Ruderman G A. Monitoring of Solid Rocket Motors[M]. Manhattan: John Wiley & Sons， 2009.
[14] Lopatin C， Grinstein D. Active Sensing for Monitoring the Properties of Solid Rocket Motor Propellant Grains[J]. Propellants Explosives Pyrotechnics， 2015， 40(2):295-302.
[15] Giurgiutiu V. Structural Health Monitoring with Piezoelectric Wafer Active Sensors[J]. Second Edition British Journal of Ophthalmology， 2014， 58(4): 438-54.
[16] 张波，董可海，张春龙，等. 固体火箭发动机健康监测系统及其关键技术研究[J]. 舰船电子工程， 2013， 33(10): 88-91.
[17] Chelner H. Embedded Sensor Technology for Solid Rocket Motor Health Monitoring[R]. OMB No. 0704-0188， 2002.
[18] Cuc A， Giurgiutiu V， Joshi S， et al. Structural Health Monitoring with Piezoelectric Wafer Active Sensors for Space Applications[J]. AIAA Journal， 2007， 45(12):2838-2850.
[19] Bois C， Hochard C. Monitoring of Laminated Composites Delamination Based on Electromechanical Impedance Measurement[J]. Journal of Intelligent Material Systems & Structures， 2004， 15(1): 59-67.
[20] Liang C， Sun F P， Rogers C A， et al. An Impedance Method for Dynamic Analysis of Active Material Systems[J]. Journal of Intelligent Material Systems and Structures， 1994， 116(1): 323-334.
[21] 熊先锋. 压电阻抗技术用于结构健康监测的研究[D]. 长沙: 国防科学技术大学， 2003.
[22] Soh C K， Bhalla S. Calibration of Piezo-Impedance Transducers for Strength Prediction and Damage Assessment of Concrete[J]. Smart Materials & Structures， 2005， 14(4).
[23] Talakokula V， Bhalla S， Ball R J， et al. Diagnosis of Carbonation Induced Corrosion Initiation and Progression in Reinforced Concrete Structures Using Piezo-Impedance Transducers[J]. Sensors & Actuators A： Physical， 2016， 242: 79-91.
[24] Bhalla S， Moharana S， Talakokula V， et al. Piezoelectric Materials: Applications in SHM， Energy Harvesting and Biomechanics[M]. India: Ane Books Pvt Ltd， 2016.
[25] 吴迪. 一维梁结构PZT压电阻抗法理论与试验研究[D]. 大连: 大连理工大学， 2011.
[26] 范夕萍，刘子如，孙莉霞，等. NEPE—5固体推进剂物理老化的动态力学性能[J]. 含能材料， 2002， 10(3): 132-135.
[27] 沈庭芳，高呜，赵伯华. 应力松弛模量与复模量转换计算的工程方法[J]. 兵工学报， 1995， (3): 40-44.
[28] 徐茂华. 结构损伤检测PZT阻抗法的理论与试验研究[D]. 武汉:华中科技大学， 2005.
[29] 庞爱民，马新刚，唐承志. 固体火箭推进剂理论与工程[M]. 北京:中国宇航出版社， 2014.
[30] Layton L H. Chemical Structural Aging Studies on a HTPB Propellant[R]. AFRPL-TR-75-13， 1975.

压电阻抗技术监测固体推进剂老化研究

Impedance Characterization and Validation of Solid Propellant Based on Electro-Mechanical Impedance Method

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价